Home > Fuel Gauge > F-150 Dual Tank Fuel Gauge Not Working

F-150 Dual Tank Fuel Gauge Not Working


It is trying to prime the gas to start, but wont start?? FYI: The most common fuel tank used in the '67-'72 era of Ford trucks is the in-cab tank. controls hold 18.5 gallons, and a 21.5-gallon version was also available. Top Bweckbacher New Member Posts: 1 Joined: Fri Dec 18, 2015 9:11 pm Truck: 1988 F250 diesel My Truck Mods Re: Dual Fuel Tanks Fuel Gauge Problem Quote Postby Bweckbacher » have a peek at this web-site

Measuring the resistance in the 'Empty' position of the float gave readings between 67-70 ohms. I ask how that could happen and he says it probably happened when I replaced the fuel pump. George Vassallo 169,336 views 13:49 1984-1994 Ford Self Diagnostics Test - KOER ( Key On Engine Running ) - Duration: 10:39. I'm only going to be covering factory setups on this page, however, since the vast array of aftermarket auxiliary fuel tank setups would obviously make this tutorial an impossible task.

Ford F150 Gas Gauge Not Working

That afternoon, and evening, I drive the truck all over town and I realize that I must have really needed a tune up because I am getting great gas mileage. Anyway, I pour a little gas down the throat of the carb and the old truck fires up and runs as usual. Some trucks use a short jumper harness between the dash switch & the dash harness - check, and clean those terminals. Not good, but it runs.

When you probe the connector, your test light should flash on and off. Up next Fixing Gas Gauge on 95-2002 Ford - Duration: 4:10. Mark helpful 76,615 Report tennisshoes answered 3 years ago Ford had a lot of trouble with the switching valve in the frame, it would switch tanks but the sender part of F250 Fuel Gauge Not Working Yes No The gauge and wiring are good.

If you're going an aftermarket gauge, depending on who you get it from, you might have to use their sending unit. When I switch the tank to the rear it drops to empty. Published on Apr 12, 2013i'm going to show you how to fix your fuel gauge the easy way before you buy new part when it can just be a bad ground Watch Queue Queue __count__/__total__ Find out whyClose how to fix a fuel gauge problem for ford and many more JUSTAGEARHEAD SubscribeSubscribedUnsubscribe5858 Loading...

The sending unit must be removed for further testing. 2001 Ford Expedition Fuel Gauge Not Working Top Renton53 New Member Posts: 6 Joined: Sat Apr 21, 2012 9:13 am Truck: 1988 Ford F150 XLT Lariat- 5.0L 302 EFI- AOD Trans My Truck Mods Re: Dual Fuel Tanks On Sunday I reinstalled the carb and the truck STILL WON'T START. Quick Disconnect DIY - Duration: 8:01.

F150 Fuel Gauge Stuck On Empty

The back unit showing empty sounds like a sending unit. The later style was for use with a printed circuit board. (click to enlarge) You can test the IPVR without pulling the instrument cluster. Ford F150 Gas Gauge Not Working Reconnect the gauge wiring to the unit and ground the unit. Ford F250 Fuel Gauge Problem Dual Fuel Tanks Fuel Gauge Problem Post Reply Print view Search Advanced search 9 posts • Page 1 of 1 Renton53 New Member Posts: 6 Joined: Sat Apr 21, 2012 9:13

Now that that is fixed the rear gauge now pegs at full and not Empty. Check This Out BTW - all electric gauges are the same. Jennies Garage 184,726 views 5:41 Fuel Gauge Tech - How To Properly Diagnose a Faulty Fuel Pump Sending Unit - Duration: 3:46. So i'm suspecting a similar situation in the rear, I'll have to drop that tank and see what's going on.Thanks again! Ford Explorer Gas Gauge Not Working

  1. I have a 1988 Ford F150 with dual fuel tanks.
  2. Most aftermarket gauges are not for use with a factory Ford sending unit.
  3. The other would be to purchase one of our 240-33ohm scaled gauges and the matching #3262 sending unit, or if this unit will not fit your specific tank type, a similar
  4. Ford went from a IVR voltage system to a magnetic system on the fuel sender system so if you lost connection with the sender the gauge would go full scale just
  5. Top kg5ie Senior Member Posts: 730 Joined: Fri Jul 08, 2011 3:37 pm Truck: 95 4x4 XLT 5.0 4R70W Location: TX My Truck Mods Re: Dual Fuel Tanks Fuel Gauge Problem
  6. So, I figure it can't be getting any gas.
  7. The gas gauge (front tank) hasn't moved at all.
  8. Fig. 2 Fig. 3 Fig. 4 Here are some general close-ups of the in-cab fuel tank sending unit.

I was actually out of gas all this time. Engineering Nonsense 23,405 views 4:10 Diagnosis of Stuck Fuel Gauge- Is it Gauge or Sending Unit? - Duration: 16:23. The fuel filter seems OK but I poke a hole through it just to be sure. Source Skip navigation UploadSign inSearch Loading...

I tell him to go ahead and tune up the truck as long as he has it there. 2002 Ford Explorer Fuel Gauge Not Working Most sending units have universal flanges that will work in any tank unless it is home made. Airtex/ASC Performance Pumps 197,327 views 3:46 Fuel gauge reads wrong after fuel pump replaced - Duration: 5:09.

what should I do? 1 answer I replaced the fuel pump in the front fuel tank 1992 Ford F-150 STD 4WD Extended Cab SB - Maintenance & Repair 1991 F-150 4x4

Rating is available when the video has been rented. Move the float arm up and down. This removes the resistance supplied by the sending unit, and should cause the gauge to swing over to the 'Full' position. Fuel Gauge Always Reads Full The next day I pick up the truck and the mechanic tells me that the gas in the front tank is fine.

The higher the fuel level, the higher the float raises, which decreases the resistance between gauge and ground. Chris Ingrassia 29,089 views 7:57 Repairing Fuel Gauge Problems 2004 Mercury Marquis -EricTheCarGuy - Duration: 23:11. See Fig. 6 for the typical location on the backside of the instrument panel. have a peek here Fig. 8 For educational purposes I hooked this sending unit up to both a digital and an analog ohmmeter to compare the readings.

NOTE: You MUST make sure your ohmmeter is capable of reading the range needed...many inexpensive hardware-store variety units are not designed to measure that fine a range. I only use the truck occasionally and at times it sits too long without running but it never has failed to start no matter how long I leave it idle. Loading... Please try the request again.

Tyrone Williams 44,657 views 4:13 Fuel Sending Unit Repair | Ford F250 / F350 7.3L Powerstroke Diesel - Duration: 2:56. Your cache administrator is webmaster. On Saturday I try to buy I rebuilt carburetor but I have a California truck in New Jersey.